Kia Forte: Power Train / Transmission Gear Oil (DCT)

Kia Forte 2019-2025 (BD) Service Manual / Maintenance / Power Train / Transmission Gear Oil (DCT)

Repair procedures
Inspection

Oil level check

1.

Remove the under cover.

D 1.6 TCI-NEW U (Refer to Engine Mechanical System - "Engine Room Under Cover")

G 1.6 T-GDI GAMMA (Refer to Engine Mechanical System - "Engine Room Under Cover")

2.

Remove the oil filler plug (A).

[NEW U 1.6 TCI, GAMMA 1.6 T-GDI]

3.

Check the condition of the oil and make sure that it is at the proper level (A).

4.

Install the oil filler plug (A).

[NEW U 1.6 TCI, GAMMA 1.6 T-GDI]

Tightening torque :

58.9 - 78.5 N·m (6.0 - 8.0 kgf·m, 43.4 - 57.8 lb·ft)

  

The existing oil filler plug gasket must be replaced with a new one. (Do not reuse it.)

5.

Install the under cover.

D 1.6 TCI-NEW U (Refer to Engine Mechanical System - "Engine Room Under Cover")

G 1.6 T-GDI GAMMA (Refer to Engine Mechanical System - "Engine Room Under Cover")

Spark Plug
Repair procedures Inspection [On vehicle inspection] 1. Accelerate the engine to about 3,000 rpm 3 times or more. 2. Remove the spark p ...

Valve Clearance
Repair procedures Inspection [Gamma 1.6 MPI/T-GDI] Check the valve clearance. If necessary, adjust the valve clearance by replacing the tappets. – For valve clearance ...

Other information:

Kia Forte 2019-2025 (BD) Owners Manual: Winter driving


Severe weather conditions in the winter result in greater wear and other problems. To minimize the problems of winter driving, you should follow these suggestions: Snowy or icy conditions To drive your vehicle in deep snow, it may be necessary to use snow tires on your tires. If snow t ...

Kia Forte 2019-2025 (BD) Owners Manual: LED Headlamp, Washer Fluid, Hood open Warning Lights


LED Headlamp Warning Light This warning light illuminates: Once you set the Engine Start/Stop Button to the ON position. - It illuminates for approximately 3 seconds and then goes off. When there is a malfunction with the LED headlamp. In this situation, have the vehicle ...

Copyright © www.kiforte.com 2017-2025